纺织学报 ›› 2020, Vol. 41 ›› Issue (06): 76-80.doi: 10.13475/j.fzxb.20190904705

• 染整与化学品 • 上一篇    下一篇

己酸酯淀粉的制备及其上浆性能

李伟1(), 景元炜1, 张正桥1, 倪庆清2, 徐珍珍1, 刘新华1   

  1. 1.安徽工程大学 纺织服装学院, 安徽 芜湖 241000
    2.信州大学 纤维学部, 日本 长野 3868576
  • 收稿日期:2019-09-17 修回日期:2020-02-28 出版日期:2020-06-15 发布日期:2020-06-28
  • 作者简介:李伟(1986—),男,副教授,博士。主要研究方向为纺织浆料的开发与研究。E-mail:fangzhiliweiwu@sina.com
  • 基金资助:
    安徽省自然科学基金面上项目(1908085ME124);安徽省重点研发计划项目(201904a06020001);芜湖市科技计划项目(2018pt04)

Preparation and sizing properties of caproylated starch

LI Wei1(), JING Yuanwei1, ZHANG Zhengqiao1, NI Qingqing2, XU Zhenzhen1, LIU Xinhua1   

  1. 1. College of Textiles and Garments, Anhui Polytechnic University, Wuhu, Anhui 241000, China
    2. Faculty of Textile Science and Technology, Shinshu University, Nagano 3868567, Japan
  • Received:2019-09-17 Revised:2020-02-28 Online:2020-06-15 Published:2020-06-28

RichHTML

4

PDF (PC)

100

摘要：

为开发适合疏水性纤维特别是聚乳酸纤维经纱上浆的变性淀粉浆料品种,以己酸酐(CA)为酯化剂,通过改变其用量制备了不同取代度的己酸酯淀粉(CS)。对CS颗粒结构进行了红外光谱分析,探究了己酸酯化变性对淀粉浆液性能、浆膜力学性能的影响。结果表明:经己酸酯化变性后,淀粉浆液的黏度热稳定性、淀粉对聚乳酸和涤纶纤维的黏附性及淀粉膜的断裂伸长率均得到了提升,膜的断裂强度有所降低;CS对2种纤维的黏附力,在取代度小于0.025时逐渐提高,且在0.025时取得最大值,然后随取代度增加而有所降低;CS膜的断裂伸长率随取代度增大而提高,断裂强度逐渐降低;CS浆液的黏度热稳定性逐渐降低,但均高于酸解淀粉。

关键词: 淀粉, 浆料, 己酸酯化, 黏附性, 浆膜性能, 上浆性能

Abstract:

In order to provide a suitable modified starch for warp sizing of hydrophobic fibers especially for polylactic acid (PLA) fibers, caproylated starch (CS) samples with different degrees of substitution were prepared by using caproic anhydride as esterifying agent. The structure of CS was characterized by Fourier transform infrared analysis. The influence of the caproylation on paste and film properties was investigated. The results show that the caproylation could enhance viscosity stability of gelatinized starch paste, its adhesion to polylactic acid and polyester fibers, and breaking elongation of starch film. In addition, the modification causes decrease in tensile strength of starch film. When the degrees of substitution are below 0.025, the adhesion demonstrats a gradual increase, and it reaches the highest value at 0.025 and then gradually decreases. The elongation of CS film rose gradually but the strength reduced. The stabilities of the CS pastes are worsened as the degree of substitution is increased, but are higher than that of acid-converted corn starch paste.

Key words: starch, sizing agent, caproylation, adhesion, film property, sizing property

中图分类号: 

  • TS103.846

图1

淀粉己酸酯化合成CS的反应方程"

图2

ACS和CS的红外光谱曲线"

图3

CS样品的扫描电镜照片(×2 000)"

图4

CS浆液的黏度及黏度热稳定性"

图5

己酸酯化变性对淀粉黏附性的影响"

图6

己酸酯化变性对淀粉浆表面张力的影响"

图7

己酸酯化变性对淀粉浆膜力学性能的影响"

[1] MARAN J P, SIVAKUMAR V, SRIDHAR R, et al. Development of model for mechanical properties of tapioca starch based edible films[J]. Industrial Crops and Products, 2013,42(1):159-168.
[2] 周永元. 纺织浆料学[M]. 北京: 中国纺织出版社, 2004: 1-12.
ZHOU Yongyuan. Theory of textile warp sizes[M]. Beijing: China Textile and Apparel Press, 2004: 1-12.
[3] 张朝辉, 徐珍珍, 刘新华, 等. 乙酰乙酸酯化淀粉浆料的制备及其性能[J]. 纺织学报, 2017,38(11):68-72.
ZHANG Chaohui, XU Zhenzhen, LIU Xinhua, et al. Preparation and properties of acetoacetylated starch used as sizing agent[J]. Journal of Textile Research, 2017,38(11):68-72.
[4] 张朝辉, 徐珍珍, 李伟, 等. 季铵阳离子醚化-十二烯基琥珀酸酯化淀粉浆料的黏附性能[J]. 纺织学报, 2018,39(12):67-71, 77.
ZHANG Chaohui, XU Zhenzhen, LI Wei, et al. Adhesion properties of quaternary ammonium cation-esterified dodecenylsuccinic anhydride-etherified starch size[J]. Journal of Textile Research, 2018,39(12):67-71, 77.
[5] 李伟, 刘新华, 徐珍珍, 等. 电中性双重醚化淀粉浆料的制备及其浆膜性能[J]. 纺织学报, 2017,38(12):81-86.
LI Wei, LIU Xinhua, XU Zhenzhen, et al. Preparation and film properties of electroneutral double-etherified corn starch[J]. Journal of Textile Research, 2017,38(12):81-86.
[6] JOHN M J, ANANDJIWALA R, OKSMAN K, et al. Melt-spun polylactic acid fibers: effect of cellulose nanowhiskers on processing and properties[J]. Journal of Applied Polymer Science, 2013,127(1):274-281.
[7] SINGH J, KAUR L, MCCARTHY O J. Factors influencing the physico-chemical, morphological, thermal and rheological properties of some chemically modified starches for food applications-a review[J]. Food Hydrocolloids, 2007,21(1):1-22.
[8] LI W, XU Z Z, WANG Z Q, et al. Double etherification of corn starch to improve its adhesion to cotton and polyester fibers[J]. International Journal of Adhesion and Adhesives, 2018,84:101-107.
[9] 郭蕉兰, 张燕萍. 羧甲基淀粉钠-脂肪酸淀粉酯性质的研究[J]. 食品科技, 2014,39(7):272-276.
GUO Jiaolan, ZHANG Yanping. Property of carboxymethyl starch fatty acid esters[J]. Food Science and Technology, 2014,39(7):272-276.
[10] 汪源浩, 具本植, 张淑芬. 高黏度、高热稳定性羧甲基淀粉己酸酯的溶液性质[J]. 化工学报, 2013,64(1):275-282.
WANG Yuanhao, JU Benzhi, ZHANG Shufen. Aqueous solution properties of carboxymethyl starch hexanoate with high viscosity and thermal stability[J]. CIESC Journal, 2013,64(1):275-282.
[11] ZHU Z F, CHEN P H. Carbamoyl ethylation of starch for enhancing the adhesion capacity to fibers[J]. Journal of Applied Polymer Science, 2007,106(4):2763-2768.
[12] BISMARK S, ZHU Z F. Amphipathic starch with phosphate and octenylsuccinate substituents for strong adhesion to cotton in warp sizing[J]. Fibers and Polymers, 2018,19(7):1850-1860.
[13] LI W, XU Z Z, WANG Z Q, et al. Tertiary amination/hydroxypropylsulfonation of cornstarch to improve the adhesion-to-fibers and film properties for warp sizing[J]. Fibers and Polymers, 2018,19(7):1386-1394.
[14] LI W, XU Z Z, WANG Z Q, et al. One-step quaternization/hydroxypropylsulfonation to improve paste stability, adhesion and film properties of oxidized starch[J]. Polymers, 2018,10(10):1110.
[15] ZHU Z F, XU D S, GUO J S, et al. Comparative study on sizing properties of amphoteric starch and phosphorylated starch for warp sizing[J]. Fibers and polymers, 2012,13(2):177-184.
[16] WANG Y B, XIE W L. Synjournal of cationic starch with a high degree of substitution in an ionic liquid[J]. Carbohydrate Polymers, 2010,80(4):1172-1177.
doi: 10.1016/j.carbpol.2010.01.042
[17] ALISHAHI A, FARAHNAKY A, MAJZOOBI M, et al. Physicochemical and textural properties of corn starch gels: effect of mixing speed and time[J]. Food Hydrocolloids, 2015,45:55-62.
doi: 10.1016/j.foodhyd.2014.11.005
[18] LI W, ZHU Z F. Electroneutral maize starch by quaterization and sulfosuccination for strong adhesion-to-viscose fibers and easy removal[J]. Journal of Adhesion, 2016,92(4):257-272.
doi: 10.1080/00218464.2015.1025953
[19] WU S H. Polymer interface and adhesion[M]. New York: Marcel Dekker, 1982: 359-448.
[1] 李伟, 张正桥, 吴兰娟, 徐珍珍, 倪庆清, 鲁育豪. 磷酸酯-己酸酯化淀粉的制备及其浆膜性能[J]. 纺织学报, 2020, 41(10): 81-86.
[2] 段方燕, 王闻宇, 金欣, 牛家嵘, 林童, 朱正涛. 淀粉纤维的成形及其载药控释研究进展[J]. 纺织学报, 2020, 41(10): 170-177.
[3] 李伟, 张正桥, 吴兰娟, 吴杰, 祝志峰. 双亲性淀粉浆料的研究进展[J]. 纺织学报, 2020, 41(07): 182-187.
[4] 沈艳琴, 杨树, 武海良, 王忠梁. 浆纱用中低温水溶性淀粉浆料的研究进展[J]. 纺织学报, 2019, 40(06): 142-151.
[5] 周步光, 王平, 王强, 范雪荣, 袁久刚. 辣根过氧化物酶在纤维材料生物整理中的应用研究进展[J]. 纺织学报, 2019, 40(04): 170-176.
[6] 汪风波, 王加毅, 孙正, 马颜雪, 吕迎智, 张魏峰, 吕艳, 吕明明, 陈思雨, 李毓陵, 陈小光. 聚丙烯酸酯浆料废水处理中试研究[J]. 纺织学报, 2019, 40(01): 108-113.
[7] 郭淑华 王建坤 钱晓明. 微波辅助羧甲基玉米淀粉的制备及其上浆性能[J]. 纺织学报, 2018, 39(12): 59-66.
[8] 张朝辉 徐珍珍 李伟. 季铵阳离子醚化-十二烯基琥珀酸酯化淀粉浆料的黏附性能[J]. 纺织学报, 2018, 39(12): 67-71.
[9] 王建坤 郭晶 张昊 郑帼. 交联氨基淀粉对亚甲基蓝染料的吸附性能[J]. 纺织学报, 2018, 39(11): 103-110.
[10] 张朝辉 徐珍珍 徐文正 李伟. 季铵阳离子型接枝淀粉浆料的浆膜性能[J]. 纺织学报, 2018, 39(11): 68-72.
[11] 曹新伟 宋秦杰 朱博 刘建立 王鸿博 高卫东. 冷水可溶性马铃薯淀粉的低温上浆性能[J]. 纺织学报, 2018, 39(03): 79-85.
[12] 李伟 刘新华 徐珍珍 李长龙 王旭 魏安方 张朝辉. 电中性双重醚化淀粉浆料的制备及其浆膜性能[J]. 纺织学报, 2017, 38(12): 77-82.
[13] 沈艳琴 武海良 熊锐 毛宁涛. 中低温水溶季铵阳离子淀粉浆料的合成及其浆纱性能[J]. 纺织学报, 2017, 38(11): 73-78.
[14] 张朝辉 徐珍珍 刘新华 李伟. 乙酰乙酸酯化淀粉浆料的制备及其性能[J]. 纺织学报, 2017, 38(11): 68-72.
[15] 武海良 姚一军 沈艳琴 毛宁涛. 浆料混溶性对共混浆膜力学性能的影响[J]. 纺织学报, 2017, 38(10): 65-69.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
京ICP备14006648号　 京公网安备11010502044800号
版权所有 © 2021 《纺织学报》编辑部
地址： 北京市朝阳区延静里中街3号主楼6层《纺织学报》杂志社　邮政编码：100025　
电话：010-65017711,65917740　传真：010-65016539　Email:fangzhixuebao@vip.126.com
本系统由北京玛格泰克科技发展有限公司设计开发