纺织学报 ›› 2019, Vol. 40 ›› Issue (09): 1-7.doi: 10.13475/j.fzxb.20180806707

• 纤维材料 •    下一篇

静电纺聚四氟乙烯/二氧化钛光催化纳米纤维膜的制备及其应用

张梦媛1,2, 黄庆林1,2(), 黄岩1,2, 肖长发1   

  1. 1.天津工业大学 分离膜与膜过程国家重点实验室, 天津 300387
    2.天津工业大学 材料科学与工程学院, 天津 300387
  • 收稿日期:2018-08-27 修回日期:2019-05-09 出版日期:2019-09-15 发布日期:2019-09-23
  • 通讯作者: 黄庆林
  • 作者简介:张梦媛(1992—),女,硕士。主要研究方向为疏水膜的制备及应用。
  • 基金资助:
    国家自然科学基金青年基金项目(21404079);中国科协青年人才托举工程项目(YESS20160168)

Electrospun poly(tetrafluoroethylene)/TiO2 photocatalytic nanofiber membrane and its application

ZHANG Mengyuan1,2, HUANG Qinglin1,2(), HUANG Yan1,2, XIAO Changfa1   

  1. 1. State Key Laboratory of Separation Membranes and Membrane Processes, Tiangong University, Tianjin 300387, China
    2. School of Materials Science and Engineering, Tiangong University, Tianjin 300387, China
  • Received:2018-08-27 Revised:2019-05-09 Online:2019-09-15 Published:2019-09-23
  • Contact: HUANG Qinglin

RichHTML

13

PDF (PC)

281

摘要：

针对光催化剂二氧化钛(TiO2)难回收、传统载体材料性能不稳定等问题,以聚四氟乙烯(PTFE)为成膜聚合物,以聚乙烯醇(PVA)为纺丝载体,引入纳米光催化剂TiO2,采用乳液静电纺丝法制备PTFE/PVA/TiO2初生纤维膜,然后经烧结得到负载型PTFE/TiO2光催化纳米纤维膜。通过形貌观察、孔径、孔隙率以及疏水性能测试,考察TiO2质量分数对纤维膜结构与性能的影响。结果表明:随着TiO2固含量的增加,纤维膜直径均匀性有所降低,平均孔径增大;将纤维膜用于减压膜蒸馏实验,通量最高达35 L/(m2·h),截盐率稳定在99.98%以上;在光催化降解质量浓度为10 mg/L的亚甲基蓝染料水溶液过程中,经紫外线照射5 h后,染料降解率达99%;经重复使用后,PTFE/TiO2纳米纤维膜仍能保持良好的结构与光催化性能。

关键词: 聚四氟乙烯, 二氧化钛, 静电纺丝, 光催化, 减压膜蒸馏

Abstract:

In order to solve the difficult recovery of photocatalyst titanium dioxide (TiO2) and unstable performance of the conventional carrier materials, poly(tetrafluoroethylene) (PTFE) was used as a stable TiO2 carrier, and polyvinyl alcohol (PVA) was used as the spinning carrier. The PTFE/PVA/TiO2 precursor fiber membrane was obtained by emulsion electrospinning, and then the PTFE/TiO2 photocatalytic nanofiber membrane was obtained after sintering. The effects of the amount of titanium dioxide on the structure and properties of the membranes were investigated by membrane morphology observation, pore size, porosity and hydrophobicity. The results show that with the increase of TiO2 solid content, the uniformity of membrane fiber diameter decreases and the pore size increases. The membrane was used in vacuum membrane distillation experiment. The flux is up to 35 L/(m2·h) and the desalination rate is over 99.98%. At the same time, the membrane was used for photocatalytic degradation of methylene blue dye aqueous solution (concentration of 10 mg/L). The degradation ratio reaches 99% after 5 h UV irradiation. After reuse, PTFE/titanium dioxide nanofiber membranes still maintain good membrane structure and photocatalytic performance.

Key words: poly(tetrafluoroethylene), titanium dioxide, electrospinning, photocatalysis, vacuum membrane distillation

中图分类号: 

  • TQ342.71

表1

纤维膜的名称"

TiO2质量分数/% 初生纤维膜名称 烧结纤维膜名称
0.0 M-p0 M-s0
2.5 M-p1 M-s1
5.0 M-p2 M-s2
7.5 M-p3 M-s3
10.0 M-p4 M-s4

图1

静电纺丝装置示意图"

图2

纤维膜的液体渗透压测试装置"

图3

流变性能曲线"

表2

纺丝溶液非牛顿指数"

TiO2质量分数/% 非牛顿指数n
0.0 0.826 35
2.5 0.878 33
5.0 0.991 02
7.5 1.002 00
10.0 1.060 23

图4

初生纤维膜和烧结纤维膜形貌照片"

表3

纤维膜性能"

样品名称 粗糙度/nm 比表面积/(m2·g-1) 接触角/(°)
M-s0 0.634 4.222 148.90±2.0
M-s1 0.972 4.695 144.50±1.9
M-s2 1.119 5.414 144.00±2.3
M-s3 1.274 6.967 143.46±1.0
M-s4 1.313 5.707 142.67±4.3

表4

PTFE/TiO2纤维膜结构性能"

样品名称 孔隙率/
%		 平均孔径/
nm		 液体渗透压/
MPa		 断裂强度/
MPa
M-s0 63.2±0.3 580±4 0.14±0.02 2.83±0.25
M-s1 65.0±0.2 802±5 0.11±0.01 1.53±0.19
M-s2 69.5±0.3 900±3 0.09±0.01 1.11±0.27
M-s3 79.8±0.2 1 050±10 0.08±0.01 1.03±0.15
M-s4 64.6±0.1 1 460±10 0.05±0.02 0.99±1.08

图5

纤维膜的蒸馏性能"

图6

PTFE/TiO2 纤维膜光催化前后形貌照片"

图7

PTFE/TiO2纤维膜光催化降解MB效率曲线"

图8

PTFE/TiO2纤维膜光降解稳定性"

[1] 赵卓凡. 纳米二氧化钛光催化剂在环境污染治理中的应用[J]. 科技创新与应用, 2016(27):182-183.
ZHAO Zhuofan. Application of nano titanium dioxide photocatalyst in environmental pollution control[J]. Technological Innovation and Application, 2016(27):182-183.
[2] 章丹, 徐斌, 朱培娟, 等. TiO2光催化降解亚甲基蓝机理的研究[J]. 华东师范大学学报(自然科学版), 2013(5):35-42.
ZHANG Dan, XU Bin, ZHU Peijuan, et al. Study on the mechanism of photocatalytic degradation of methylene blue by TiO2[J]. Journal of East China Normal University (Natural Science Edition), 2013(5):35-42.
[3] CHUNG W J, CHUN S Y, KIM S S, et al. Photocatalytic removal of tetracycline using TiO2/Ge composite optimized by response surface methodolo-gy (RSM)[J]. Journal of Industrial & Engineering Chemistry, 2016,36:320-325.
[4] 费锡智, 杨晶晶, 白仁碧. 光催化-膜分离耦合技术的水处理应用研究进展[J]. 水处理技术, 2014(12):11-18.
FEI Xizhi, YANG Jingjing, BAI Renbi. Research progress in application of photocatalysis membrane separation coupling technology in water treatment[J]. Water Treatment Technology, 2014(12):11-18.
[5] 孙洋洋. 磁性氧化石墨烯/TiO2复合光催化剂的制备及其光催化降解染料废水的研究[D]. 西安:长安大学, 2015: 2-15.
SUN Yangyang. Preparation of magnetic graphene oxide/TiO2 composite photocatalyst and its photocatalytic degradation of dye wastewater[D]. Xi'an: Chang'an University, 2015: 2-15.
[6] OLARU N, CALIN G, OLARU L. Zinc oxide nanocrystals grown on cellulose acetate butyrate nanofiber mats and their potential photocatalytic activity for dye degradation[J]. Industrial & Engineering Chemistry Research, 2014,53(46):17968-17975.
[7] 范文娟. 光催化剂载体:羧基氟碳共聚物纤维膜的制备及耐光降解性能研究[J]. 表面技术, 2013,42(5):89-92.
FAN Wenjuan. Photocatalyst carrier: preparation of photocatalyst carrier carboxyl fluorocarbon copolymer fiber membrane and its photodegradability[J]. Surface Technology, 2013,42(5):89-92.
[8] 陈哉娜, 冯潇潇, 韩丹敏, 等. 卟啉化聚合物纤维膜负载TiO2光催化剂的制备及其光催化性能研究[J]. 化学研究与应用, 2014(7):993-996.
CHEN Zaina, FENG Xiaoxiao, HAN Danmin, et al. Preparation and photocatalytic properties of porphyrin polymer membrane loaded TiO2 photocatalyst[J]. Chemical Research and Application, 2014(7):993-996.
[9] LEE E J, AN A K, HADI P, et al. Advanced multi-nozzle electrospun functionalized titanium dioxide/polyvinylidene fluoride-co-hexafluoropropylene (TiO2/PVDF-HFP) composite membranes for direct contact membrane distillation[J]. Journal of Membrane Science, 2017,524:712-720.
doi: 10.1016/j.memsci.2016.11.069
[10] 陶丽琴, 赵义侠, 康卫民, 等. 聚四氟乙烯超细纤维负载二氧化钛光催化性能[J]. 硅酸盐学报, 2016,44(1):89-94.
TAO Liqin, ZHAO Yixia, KANG Weimin, et al. Photocatalytic properties of ultrafine PTFE fiber supported titanium dioxide[J]. J Chin Ceram Soc, 2016,44(1):89-94.
[11] MOZIA S, MORAWSKI A W. Hybridization of photocatalysis and membrane distillation for purification of wastewater[J]. Catalysis Today, 2006,118(1/2):181-188.
doi: 10.1016/j.cattod.2005.12.003
[12] HUANG Y, HUANG Q L, LIU H, et al. Preparation, characterization, and applications of electrospun ultrafine fibrous PTFE porous membranes[J]. Journal of Membrane Science, 2017(523):317-326.
[13] KO F K. Fabrication of ultrafine fibrous polytetrafluoroethylene porous membranes by electrospinning[J]. Journal of Materials Research, 2009,24(9):2755-2761.
doi: 10.1557/jmr.2009.0347
[14] FENG S, ZHONG Z, WANG Y, et al. Progress and perspectives in PTFE membrane: preparation, modification, and applications[J]. Journal of Membrane Science, 2017,549.
[15] HUANG Q L, HUANG Y, XIAO C F, et al. Electrospun ultrafine fibrous PTFE-supported ZnO porous membrane with self-cleaning function for vacuum membrane distillation[J]. Journal of Membrane Science, 2017(534):73-82.
[1] 李庆, 管斌斌, 王雅, 刘天卉, 张洛红, 樊增禄. 光敏剂敏化Cu-有机骨架对活性深蓝K-R 的高效光催化降解[J]. 纺织学报, 2020, 41(10): 87-93.
[2] 潘璐, 程亭亭, 徐岚. 聚己内酯/ 聚乙二醇大孔径纳米纤维膜的制备及其在组织工程支架中的应用[J]. 纺织学报, 2020, 41(09): 167-173.
[3] 陈千, 廖振, 徐明, 朱亚伟. 等离子体处理对聚四氟乙烯膜粘接性能的影响[J]. 纺织学报, 2020, 41(08): 15-21.
[4] 杨凯, 张啸梅, 焦明立, 贾万顺, 刁泉, 李咏, 张彩云, 曹健. 高邻位酚醛基纳米活性碳纤维制备及其吸附性能[J]. 纺织学报, 2020, 41(08): 1-8.
[5] 陈诗萍, 陈旻, 魏岑, 王富军, 王璐. 医用防护服的构效特点及其研发趋势[J]. 纺织学报, 2020, 41(08): 179-187.
[6] 陈文豆, 张辉, 陈天宇, 武海良. 二氧化钛水热改性涤/ 棉混纺织物的自清洁性能[J]. 纺织学报, 2020, 41(07): 122-128.
[7] 吴红, 刘呈坤, 毛雪, 阳智, 陈美玉. 柔性ZrO2 纳米纤维膜的制备及其应用研究现状[J]. 纺织学报, 2020, 41(07): 167-173.
[8] 王树博, 秦湘普, 石磊, 庄旭品, 李振环. 氧化石墨烯量子点/ 聚丙烯腈纳米纤维复合质子交换膜的制备及其性能[J]. 纺织学报, 2020, 41(06): 8-13.
[9] 郝志奋, 徐乃库, 封严, 段梦馨, 肖长发. 聚甲基丙烯酸酯/ 聚丙烯酸酯共混纤维膜制备及其油水分离性能[J]. 纺织学报, 2020, 41(06): 21-26.
[10] 贾琳, 王西贤, 陶文娟, 张海霞, 覃小红. 聚丙烯腈抗菌复合纳米纤维膜的制备及其抗菌性能[J]. 纺织学报, 2020, 41(06): 14-20.
[11] 洪贤良, 陈小晖, 张建青, 刘俊杰, 黄晨, 丁伊可, 洪慧. 静电纺多级结构空气过滤材料的研究进展[J]. 纺织学报, 2020, 41(06): 174-182.
[12] 王婷婷, 刘梁, 曹秀明, 王清清. 竹红菌素-聚( 甲基丙烯酸甲酯-co-甲基丙烯酸)纳米纤维的制备及其光敏抗菌性能[J]. 纺织学报, 2020, 41(05): 1-7.
[13] 孙范忱, 郭静, 于跃, 张森. 聚羟基脂肪酸酯/ 海藻酸钠纳米纤维的制备及其性能[J]. 纺织学报, 2020, 41(05): 15-19.
[14] 钱怡帆, 周堂, 张礼颖, 刘万双, 凤权. 聚丙烯腈/ 醋酸纤维素/ TiO2 复合纳米纤维膜的制备及其光催化降解性能[J]. 纺织学报, 2020, 41(05): 8-14.
[15] 吴横, 金欣, 王闻宇, 朱正涛, 林童, 牛家嵘. 聚丙烯腈/ 硝酸钠纳米纤维膜的制备及其压电性能[J]. 纺织学报, 2020, 41(03): 26-32.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
京ICP备14006648号　 京公网安备11010502044800号
版权所有 © 2021 《纺织学报》编辑部
地址： 北京市朝阳区延静里中街3号主楼6层《纺织学报》杂志社　邮政编码：100025　
电话：010-65017711,65917740　传真：010-65016539　Email:fangzhixuebao@vip.126.com
本系统由北京玛格泰克科技发展有限公司设计开发