纺织学报 ›› 2021, Vol. 42 ›› Issue (05): 109-114.doi: 10.13475/j.fzxb.20200900207

• 染整与化学品 • 上一篇    下一篇

等离子体接枝丙烯酸改性聚丙烯腈导电纳米纤维纱线的制备

刘晓倩, 陈玉, 周惠敏, 闫源, 夏鑫()   

  1. 新疆大学 纺织与服装学院, 新疆 乌鲁木齐 830046
  • 收稿日期:2020-09-01 修回日期:2021-01-27 出版日期:2021-05-15 发布日期:2021-05-20
  • 通讯作者: 夏鑫
  • 作者简介:刘晓倩(1995—),女,硕士生。主要研究方向为导电纺织材料。
  • 基金资助:
    国家自然科学基金项目(51763022);新疆自治区研究生教育教学改革项目(XJ2019GY10)

Preparation of polyacrylonitrile conductive nanofiber yarn grafted with acrylic acid using plasma technology

LIU Xiaoqian, CHEN Yu, ZHOU Huimin, YAN Yuan, XIA Xin()   

  1. College of Textile and Clothing, Xinjiang University, Urumqi, Xinjiang 830046, China
  • Received:2020-09-01 Revised:2021-01-27 Online:2021-05-15 Published:2021-05-20
  • Contact: XIA Xin

RichHTML

18

PDF (PC)

57

摘要：

为提高聚吡咯在聚丙烯腈纳米纤维纱线表面的粘附牢度,增加纳米纤维纱线表面的亲水性,采用常温常压等离子体技术对聚丙烯腈纳米纤维纱线表面进行丙烯酸接枝改性处理,再通过原位聚合法制备聚吡咯导电纳米纤维纱线;探讨了等离子体接枝改性的最佳处理次数和接枝时间,研究了吡咯单体浓度、氧化剂用量、掺杂剂浓度和反应时间等对聚丙烯腈纳米纤维纱线导电性的影响。结果表明:当等离子体处理功率为100 W,接枝时间为4 h,接枝2次时,聚丙烯腈纳米纤维纱线的吸水率由未处理时的227.21%提升至350.31%,纱线的质量增加率可达90%;在吡咯浓度为0.6 mol/L,三氯化铁浓度为0.8 mol/L,盐酸浓度为0.6 mol/L,0 ℃条件下反应4 h时,聚丙烯腈纳米纤维纱线的电导率提高到4.589 S/cm。

关键词: 常温常压等离子体, 接枝, 原位聚合法, 纳米纤维纱线, 电导率, 丙烯酸, 聚吡咯, 聚丙烯纤维

Abstract:

In order to improve the adhesion fastness of polypyrrole on the surface of polyacrylonitrile nanofiber yarn and improve the surface hydrophilicity of nanofiber yarn, the surface of polyacrylonitrile nanofiber yarn was grafted with acrylic acid by plasma technology at ambient temperature and pressure, and the conductive nanofiber yarn of polypyrrole was prepared by in-situ polymerization. The optimal treatment time and grafting time of plasma grafting modification were discussed, and the effects of pyrrole monomer concentration, oxidant dosage, dopant concentration and reaction time on the electrical conductivity of polyacrylonitrile nanofiber yarn were analyzed. The results show that when the plasma power is 100 W, the grafting time is 4 h, the water absorption rate is increased from 227.21% to 350.31%, and the mass increase rate of polypyrrole is up to 90%. With concentrations of pyrrole being 0.6 mol/L, ferric chloride 0.8 mol/L, hydrochloric acid 0.6 mol/L, and the reaction time is 0 ℃ for 4 h, the conductivity of polyacrylonitrile nanofiber yarn is increased to 4.589 S/cm.

Key words: normal temperature and pressure plasma, graft, in-situ polymerization, nanofiber yarn, electrical conductivity, arylic acid, polypyrrole, polyacrylonitrile fiber

中图分类号: 

  • TQ342.83

图1

不同次数等离子体和接枝处理的PAN纳米纤维纱线的扫描电镜照片(×5 000)"

图2

PAN纳米纤维纱线在等离子体和接枝处理时可能发生的反应"

图3

等离子体和接枝处理次数对PAN纳米纤维纱线接枝率和吸水率的影响"

图4

不同吡咯浓度的PAN纳米纤维纱线的表面形貌照片(×500)"

图5

吡咯浓度对PAN纳米纤维纱线质量增加率和电导率的影响"

图6

三氯化铁浓度对PAN纳米纤维纱线质量增加率和电导率的影响"

图7

盐酸浓度对PAN纳米纤维纱线质量增加率和电导率的影响"

图8

反应时间对PAN纳米纤维纱线质量增加率和电导率的影响"

图9

不同PAN试样的红外光谱图"

[1] 张晓峰, 李国豪, 胡吉永, 等. 用于人体上肢运动姿态监测的聚吡咯导电织物的机电性能评价[J]. 中国生物医学工程学报, 2015,34(6):670-676.
ZHANG Xiaofeng, LI Guohao, HU Jiyong, et al. Mechanic-electrical property characterization of PPy coated conductive woven fabric for human upper limbmotion monitoring[J]. Chinese Journal of Biomedical Engineering, 2015,34(6):670-676.
[2] LI Y, CHENG X Y, LEUNG M Y, et al. A flexible strain sensor from polypyrrole-coated fabric[J]. Synthetic Metals, 2005,155:89-94.
doi: 10.1016/j.synthmet.2005.06.008
[3] AJAY Singh, ZAKARIA Salmi, NIRAV Joshi, et al. Photo-induced synjournal of polypyrrole-silver nanocomposite films on N-(3-trimethoxysilylpropyl) pyrrole-modified biaxially oriented polyethylene flexible substrates[J]. RSC Advances, 2013,16(3):6-23.
[4] 王秀昀, 聂浩宇, 阚丽丽, 等. 聚吡咯导电薄膜原位聚合工艺的研究[J]. 化工新型材料, 2014(11):184-185.
WANG Xiuyun, NIE Haoyu, KAN Lili, et al. Study on in-situ polymerization of polypyrrole conductive film[J]. New Chemical Materials, 2014(11):184-185.
[5] ZHAO Zhiping, LI Jiding, ZHANG Danxia, et al. Nanofifiltration membrane prepared from polyacrylonitrile ultrafifiltration membrane by low-temperature plasma I: graft of acrylic acid in gas[J]. Journal of Membrane Science, 2004,232:1-8.
doi: 10.1016/j.memsci.2003.11.009
[6] YI Yang, TU Hu, ZHOU Xue, et al. Acrylic acid-grafted pre-plasma nanofibers for efficient removal of oil pollution from aquatic environment[J]. Journal of Hazardous Materials, 2019,71:165-174.
[7] 魏发云, 张伟, 邹学书, 等. 等离子体诱导丙烯酸接枝改性聚丙烯熔喷非织造材料[J]. 纺织学报, 2019,40(9):109-114.
WEI Fayun, ZHANG Wei, ZOU Xueshu, et al. Grafted modification of polypropylene melt-blown nonwowen materials with acrylic acid induced by plasma[J]. Journal of Textile Research, 2019,40(9):109-114.
[8] 姜珊, 万爱兰, 缪旭红, 等. 等离子体处理对聚吡咯/涤纶复合导电纱线性能的影响[J]. 纺织学报, 2019,40(8):95-100.
JIANG Shan, WAN Ailan, MIAO Xuhong, et al. Influence of plasma treatment on electrical conductivity of polypyrrole/polyester composite yarn[J]. Journal of Textile Research, 2019,40(8):95-100.
[9] 林佳濛, 缪旭红, 万爱兰. 等离子体预处理对聚吡咯/涤纶经编导电织物结构和性能的影响[J]. 纺织学报, 2019,40(9):97-101.
LIN Jiameng, MIAO Xuhong, WAN Ailan. Influence of plasma pretreatment on structure and properties of polypyrrole/polyester warp knitted conductive fabric[J]. Journal of Textile Research, 2019,40(9):97-101.
[10] 董猛, 田俊莹. 聚吡咯/银导电涤纶织物的开发[J]. 印染, 2015(22):1-4.
DONG Meng, TIAN Junying. Preparation of polypyrrole/Ag conductive polyester fabric[J]. China Dyeing and Finishing, 2015(22):1-4.
[11] 何青青, 徐红, 毛志平, 等. 高导电性聚吡咯涂层织物的制备[J]. 纺织学报, 2019,40(10):113-119.
HE Qingqing, XU Hong, MAO Zhiping, et al. Preparation of high-electrical conductivity polypyrrole-coated fabrics[J]. Journal of Textile Research, 2019,40(10):113-119.
[12] UPADHYAY J, KUMAR A, GOGOI B, et al. Antibacterial and hemolysis activity of polypyrrole nanotubes decorated with silver nanoparticles by an in-situ reduction process[J]. Materials Science and Engineering: C, 2015,54:8-13.
doi: 10.1016/j.msec.2015.04.027
[1] 周歆如, 周筱雅, 马咏健, 胡铖烨, 赵晓曼, 洪剑寒, 韩潇. 导电聚苯胺/聚氨酯泡沫的制备及其压力传感性能[J]. 纺织学报, 2021, 42(04): 62-68.
[2] 刘淑强, 靖逸凡, 杨雅茹, 吴改红, 余娟娟, 王凯文, 李惠敏, 李甫, 张曼. 自修复双层微胶囊的制备及其在玄武岩织物上的应用[J]. 纺织学报, 2021, 42(04): 127-131.
[3] 蔡露, 康佳良, 吕存, 何雪梅. 自交联氟化聚丙烯酸酯乳液的制备及其应用性能[J]. 纺织学报, 2021, 42(02): 161-167.
[4] 于佳, 辛斌杰, 卓婷婷, 周曦. 高导电性铜/聚吡咯涂层羊毛织物的制备与表征[J]. 纺织学报, 2021, 42(01): 112-117.
[5] 王阳, 程春祖, 姜丽娜, 任元林, 郭迎宾. 紫外光接枝/溶胶-凝胶技术制备耐久性阻燃腈纶织物[J]. 纺织学报, 2020, 41(10): 107-115.
[6] 王博, 凡力华, 原韵, 殷允杰, 王潮霞. 可拉伸聚吡咯/棉针织物的制备及其储电性能[J]. 纺织学报, 2020, 41(10): 101-106.
[7] 朱清, 徐丹丹, 潘园歌, 王成龙, 郑今欢. 水性聚丙烯酸酯对涂层商标织物图案打印效果的影响[J]. 纺织学报, 2020, 41(08): 55-62.
[8] 郝志奋, 徐乃库, 封严, 段梦馨, 肖长发. 聚甲基丙烯酸酯/聚丙烯酸酯共混纤维膜制备及其油水分离性能[J]. 纺织学报, 2020, 41(06): 21-26.
[9] 王婷婷, 刘梁, 曹秀明, 王清清. 竹红菌素-聚(甲基丙烯酸甲酯-co-甲基丙烯酸)纳米纤维的制备及其光敏抗菌性能[J]. 纺织学报, 2020, 41(05): 1-7.
[10] 胡铖烨, 缪润伍, 韩潇, 洪剑寒, GIL Ignacio. 聚乙烯醇对芳纶复合纱聚苯胺导电层耐久性影响[J]. 纺织学报, 2020, 41(04): 91-97.
[11] 王晓菲, 万爱兰. 紫外线辐照聚吡咯/银导电涤纶织物的制备[J]. 纺织学报, 2020, 41(04): 112-116.
[12] 林佳濛, 万爱兰, 缪旭红. 聚吡咯/银导电涤纶织物的制备及其性能[J]. 纺织学报, 2020, 41(03): 113-117.
[13] 陈莹, 周爽, 韦恬静, 方浩霞, 李宇菲. 聚吡咯复合织物的软模板法制备及其性能[J]. 纺织学报, 2019, 40(12): 93-97.
[14] 王访鹤, 王锐, 魏丽菲, 王照颖, 张安莹, 王德义. 层层自组装阻燃改性聚酯织物的制备及其性能[J]. 纺织学报, 2019, 40(11): 106-112.
[15] 何青青, 徐红, 毛志平, 张琳萍, 钟毅, 吕景春. 高导电性聚吡咯涂层织物的制备[J]. 纺织学报, 2019, 40(10): 113-119.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
京ICP备14006648号　 京公网安备11010502044800号
版权所有 © 2021 《纺织学报》编辑部
地址： 北京市朝阳区延静里中街3号主楼6层《纺织学报》杂志社　邮政编码：100025　
电话：010-65017711,65917740　传真：010-65016539　Email:fangzhixuebao@vip.126.com
本系统由北京玛格泰克科技发展有限公司设计开发