室外高温环境下通风服装的传热模型与实验研究

doi:10.13475/j.fzxb.20201004407

纺织学报 ›› 2021, Vol. 42 ›› Issue (06): 153-159.doi: 10.13475/j.fzxb.20201004407

室外高温环境下通风服装的传热模型与实验研究

赵敬德¹^,²(), 丁义冉¹^,², 张春红¹^,²

1. 东华大学环境科学与工程学院, 上海 201620
2. 东华大学暖通空调研究所, 上海 201620

收稿日期:2020-10-21 修回日期:2021-01-28 出版日期:2021-06-15 发布日期:2021-06-28
作者简介:赵敬德(1973—),男,副教授,博士。主要研究方向为人体热舒适性、通风服装和辐射传热。E-mail: zhaojingde@dhu.edu.cn。

Heat transfer modeling and experimental research of ventilation clothing in high-temperature outdoor environment

ZHAO Jingde¹^,²(), DING Yiran¹^,², ZHANG Chunhong¹^,²

1. College of Environmental Science and Engineering, Donghua University, Shanghai 201620, China
2. Institute of Heating, Ventilation and Air Conditioning, Donghua University, Shanghai 201620, China

Received:2020-10-21 Revised:2021-01-28 Published:2021-06-15 Online:2021-06-28

摘要/Abstract

摘要：

为提高夏季室外高温日晒环境下作业人员的热舒适性,对人体、服装与环境之间传热过程进行分析,以此作为针对性降温方式的理论基础建立了通风服装在室外高温日晒环境下的传热模型,并采用真人实验的方法验证了该传热模型;分析了送风后衣下空间空气参数及人体主观反映的改变。结果表明:采用该模型计算得到的人体得热量与失热量误差仅为9.1%,人体表面温度在10 min左右趋于稳定;给衣下空间送入处理后的冷空气时,衣下空间内空气温湿度均比未通风时低,强迫对流的存在大大地提高了体表汗液蒸发速率,人体主观热感觉与皮肤湿润感得到明显改善。

关键词: 通风服装, 传热模型, 衣下送风, 热感觉, 室外高温环境

Abstract:

In order to improve the thermal comfort of workers in the high-temperature outdoor environment in summer, the heat transfer process between the clothing and the environment in the high-temperature outdoor environment was analyzed. Through the analysis on the heat transfer process among the human body, clothing and the environment, a heat transfer model of ventilated clothing in high-temperature outdoor environment exposed to the sunlight was established, which was validated through a human subjects experiment, where the ventilation clothing is analyzed for changes in underclothing space air parameters and in subjective reflections of the human subjects. The results show that the errors in heat gain and heat loss obtained using the model are only 9.1% compared to the experimental results, and the surface temperature of the body stabilizes in about 10 min. When the cooled air is supplied into the under clothing space, the temperature and humidity of the air in the space under clothing are lower than that not ventilated. The existence of forced convection greatly increases the evaporation rate of sweat on the body surface, and the subjective heat and skin moistness are significantly improved.

Key words: ventilation clothing, heat transfer model, under clothing ventilation, thermal sensation, high-temperature outdoor environment

中图分类号:

TS941.16

赵敬德, 丁义冉, 张春红. 室外高温环境下通风服装的传热模型与实验研究[J]. 纺织学报, 2021, 42(06): 153-159.

ZHAO Jingde, DING Yiran, ZHANG Chunhong. Heat transfer modeling and experimental research of ventilation clothing in high-temperature outdoor environment[J]. Journal of Textile Research, 2021, 42(06): 153-159.

图/表 10

图1

表1

表2

图2

图3

图4

图5

图6

图7

图8

参考文献 16

[1]	姜荣, 陈亮, 象伟宁. 上海市极端高温天气变化特征[J]. 气象与环境学报, 2016, 32(1):66-74.
	JIANG Rong, CHEN Liang, XIANG Weining. Variation characteristics of extreme high temperature weather in Shanghai[J]. Journal of Meteorology and Environment, 2016, 32(1):66-74.
[2]	GAGGE A, HERRINGTON L, WINSLOW C. Thermal interchanges between the human body and its atmospheric environment[J]. American Journal of Hygiene, 1973, 26(1):84-102.
[3]	FANGER P O. Thermal comfort:analysis and applications in environmental engineering[M]. Denmark: Danish Technical Press, 1970:244.
[4]	GIBSON P. Multiphase heat and mass transfer through hygroscopic porous media with applications to clothing materials[R]. Massachusetts: Technical Report Natick/TR-97/005, 1996.
[5]	张昭华, 王云仪, 李俊. 衣下空气层厚度对着装人体热传递的影响[J]. 纺织学报, 2010, 31(12):103-107.
	ZHANG Zhaohua, WANG Yunyi, LI Jun. Influence of air layer thickness under clothing on heat transfer of dressed body[J]. Journal of Textiles Research, 2010, 31(12):103-107.
[6]	李珩, 邱义芬, 姜南, 等. 通风温度对全身通风服热防护性能影响研究[J]. 航天医学与医学工程, 2014, 27(3):205-209.
	Li Heng, QIU Yifen, JIANG Nan, et al. Influence of ventilation temperature on thermal protection performance of full-body ventilation suit[J]. Space Medicine and Medical Engineering, 2014, 27(3):205-209.
[7]	MERT Emel, PSIKUTA Agnes, BUENO Marie-Ange, et al. Effect of heterogenous and homogenous air gaps on dry heat loss through the garment, 2015, 59(11):1701-1710.
[8]	GHAZY A, BERGSTROM D J. Numerical simulation of the influence of fabric's motion on protective clothing performance during flash fire exposure[J]. Heat & Mass Transfer, 2013, 49(6):775-788.
[9]	NEVES S F, CAMPOS J B L M, MAYOR T S. Effects of clothing and fibres properties on the heat and mass transport, for different body heat/sweat releases[J]. Applied Thermal Engineering, 2017, 117:109-121. doi: 10.1016/j.applthermaleng.2017.01.074
[10]	JIA N, JIA X, AN H, et al. A 3D heat and moisture transfer model with radiation in clothing[J]. Physica A: Statal Mechanics and its Applications, 2019, 517:440-451.
[11]	UDAYRA J, WANG F. A three-dimensional conjugate heat transfer model for thermal protective clothing[J]. International Journal of Thermal Sciences, 2018, 130:28-46. doi: 10.1016/j.ijthermalsci.2018.04.005
[12]	CROCKFORD G W, PRESTIDGE M C P. A trace gas technique for measuring clothing microclimate air exchange rates[J]. British Journal of Industrial Medicine, 1972, 29(4):378-386.
[13]	曾彦彰, 邓中山, 刘静. 基于微型风扇阵列系统的人体降温空调服[J]. 纺织学报, 2007, 28(6):100-105.
	ZENG Yanzhang, DENG Zhongshan, LIU Jing. Human body cooling air-conditioning suit based on micro fan array system[J]. Journal of Textile Research, 2007, 28(6):100-105.
[14]	HADID A, YANOVICH R, ERLICH T, et al. Effect of a personal ambient ventilation system on physiological strain during heat stress wearing a ballistic vest[J]. European Journal of Applied Physiology, 2008, 104(2):311. doi: 10.1007/s00421-008-0716-8
[15]	GLITZ K J, SEIBEL U, ROHDE U, et al. Reducing heat stress under thermal insulation in protective clothing: microclimate cooling by a 'physiological' method[J]. Ergonomics the Official Publication of the Ergonomics Research Society, 2015, 58(8):1461-1469.
[16]	高黎颖. 气冷服对人体体表生理参数影响实验研究[D]. 长沙: 湖南科技大学, 2017:73-75.
	GAO Liying. Experimental study on the effect of air-cooled clothing on the physiological parameters of the human body surface[D]. Changsha: Hunan University of Science and Technology, 2017:73-75.

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed

姓别	年龄/岁	身高/cm	体重/kg
男性	23±1	175±5	72.6±4.9
女性	23±1	167±5	56.0±3.0

仪器类别	型号	精度
温度传感器	SA1-T-72热敏电阻	±0.2 Ω
温湿度计	AZ8706	±0.6 ℃ ±3% 相对湿度
热式风速仪	KANOMAX-KA23	0.01 m/s
电子秤	LQ-T2	±1 g
太阳能功率计	TES-1333	±10 W/m²

室外高温环境下通风服装的传热模型与实验研究

Heat transfer modeling and experimental research of ventilation clothing in high-temperature outdoor environment

RichHTML

PDF (PC)

摘要/Abstract

引用本文

使用本文

图/表 10

参考文献 16

相关文章 7

Metrics

本文评价

推荐阅读 0

[1]	黄倩倩, 李俊. 环境温度突变时人体热感觉变化机制研究进展[J]. 纺织学报, 2020, 41(04): 188-194.
[2]	苗苗鲁虹程梦琪. 运动前后人体体表温度变化与主观热感觉评定[J]. 纺织学报, 2018, 39(04): 116-122.
[3]	赵蒙蒙宋晓霞. 通风服装对人体热舒适的影响[J]. 纺织学报, 2017, 38(10): 94-97.
[4]	唐香宁张昭华李俊李璐瑶冯姝元 . 人体皮肤湿感觉的研究进展[J]. 纺织学报, 2017, 38(09): 174-180.
[5]	许静娴李俊刘慧娟王云仪. 热调节暖体假人在着装舒适性评价中的应用现状[J]. 纺织学报, 2017, 38(07): 164-172.
[6]	杨瑞梁周义德徐子龙. 棉纺织车间的热舒适性研究[J]. 纺织学报, 2015, 36(03): 54-57.
[7]	朱方龙;王秀娟;张启泽;张渭源. 火灾环境下应急救援防护服传热数值模拟[J]. 纺织学报, 2009, 30(04): 106-110.