纺织学报 ›› 2021, Vol. 42 ›› Issue (08): 90-95.doi: 10.13475/j.fzxb.20200808206

• 染整与化学品 • 上一篇    下一篇

黄麻纤维中黄酮类化合物提取工艺优化及表征

崔启璐1,2, 李佳蔚1, 潘柳桂1, 杨飞1,3, 郁崇文1,2()   

  1. 1.东华大学 纺织学院, 上海 201620
    2.东华大学 纺织面料技术教育部重点实验室, 上海 201620
    3.浙江金鹰股份有限公司, 浙江 舟山 316051
  • 收稿日期:2020-08-20 修回日期:2021-05-06 出版日期:2021-08-15 发布日期:2021-08-24
  • 通讯作者: 郁崇文
  • 作者简介:崔启璐(1988—),女,博士生。主要研究方向为麻纤维性能。
  • 基金资助:
    国家麻类产业技术体系项目(CARS-16)

Optimization and characterization of flavonoids extracted from jute fiber

CUI Qilu1,2, LI Jiawei1, PAN Liugui1, YANG Fei1,3, YU Chongwen1,2()   

  1. 1. College of Textiles, Donghua University, Shanghai 201620, China
    2. Key Laboratory of Textile Science & Technology, Ministry of Education, Donghua University, Shanghai 201620, China
    3. Zhejiang Golden Eagle Co., Ltd., Zhoushan, Zhejiang 316051, China
  • Received:2020-08-20 Revised:2021-05-06 Published:2021-08-15 Online:2021-08-24
  • Contact: YU Chongwen

RichHTML

14

PDF (PC)

58

摘要：

为充分开发黄麻纤维的应用价值,探究其中是否含有黄酮类化合物,采用水醇提取法制备了黄麻纤维提取液,利用紫外分光光度法测试提取液中黄酮含量,按照二次通用旋转组合设计方法对提取工艺进行优化,研究了乙醇体积分数、浴比、提取时间3个工艺因子与黄酮类化合物提取率之间的关系。对经过旋转蒸发和真空冷冻干燥后黄麻纤维提取物的化学结构、热稳定性和表面形貌进行测试与分析。结果表明:黄麻纤维提取物与芦丁标准品化学结构相似,说明其中含有黄酮类化合物,其最优提取工艺是乙醇体积分数75%,浴比1∶50,提取时间150 min, 该条件下黄酮的提取率为0.037%。

关键词: 黄麻纤维, 黄酮, 响应面分析, 提取工艺, 水醇提取法

Abstract:

In order to confirm the existence of flavonoids in jute fiber and to develop the application value, the jute fiber extracts were obtained using alcohol-water method. The content of flavonoids in the extraction solution was tested using ultraviolet spectrophotometer. The extraction process was optimized based on the use of quadratic general rotary design, and the relationships between the three factors(alcohol volume fraction, bath ratio and extracting time) and the extraction rate of flavonoids were studied. The chemical structure, thermal stability and morphology of jute fiber extracts after rotary evaporation and vacuum freeze drying were tested and analyzed. The results show that the chemical structure of jute fiber extracts is similar to the structure of rutin standard, which indicates that it contains flavonoids. The optimal extraction conditions were found to be ethanol volume fraction 75%, bath ratio 1∶50, and extracting time 150 min, at which the extraction rate of flavonoids was 0.037%.

Key words: jute fiber, flavonoid, responsive surface analysis, extraction process, alcohol-water method

中图分类号: 

  • TS121

表1

试验因子水平编码表"

水平 A
乙醇体积分数x1/%		 B
浴比x2		 C
时间x3/min
-1.682(-γ) 60 1∶30 60
-1 64 1∶34 78
0 70 1∶40 105
1 76 1∶46 132
+1.682(+γ) 80 1∶50 150

表2

试验设计及黄酮类化合物提取率"

试验号 x0 A B C 提取率ye/%
1# 1 1 1 1 0.007 8
2# 1 1 1 -1 0.012 2
3# 1 1 -1 1 0.012 2
4# 1 1 -1 -1 0.014 7
5# 1 -1 1 1 0.013 3
6# 1 -1 1 -1 0.013 3
7# 1 -1 -1 1 0.007 4
8# 1 -1 -1 -1 0.018 3
9# 1 1.682 0 0 0.004 9
10# 1 -1.682 0 0 0.003 9
11# 1 0 1.682 0 0.006 1
12# 1 0 -1.682 0 0.018 6
13# 1 0 0 1.682 0.008 7
14# 1 0 0 -1.682 0.020 1
15# 1 0 0 0 0.012 5
16# 1 0 0 0 0.023 0
17# 1 0 0 0 0.014 4
18# 1 0 0 0 0.015 3
19# 1 0 0 0 0.007 7
20# 1 0 0 0 0.017 2

表3

回归系数求解及显著性检验结果"

项目 数值 t检验 显著性
b0 0.013 2.182 476>t0.1(10) 显著
b1 -0.003 654 0.924 61<t0.1(10) 不显著
b2 -0.002 69 0.680 67<t0.1(10) 不显著
b3 -0.003 974 1.005 57<t0.1(10) 不显著
b12 -0.002 708 1.658 43<t0.1(10) 不显著
b13 0.006 855 4.197 795>t0.01(10) 显著
b23 0.004 458 2.799 45>t0.02(10) 显著
b11 -0.008 6 2.235 4>t0.05(10) 显著
b22 -0.006 5 1.689 63<t0.1(10) 不显著
b33 0.002 561 0.665 714> t0.1(10) 显著

表4

回归方程的显著性检验结果"

指标 F1 F2 Fα1 Fα2 显著性
提取率 0.66 1.68 F0.01(5,5)=11.0 F 0 . 25(9,10)=1.56 显著

图1

不同工艺及其交互作用对黄酮提取率的影响"

表5

二次通用旋转试验验证结果"

试验号 因子 指标
y/%
x1/% x2 x3/min
8# 64 1∶34 78 0.018 3
12# 70 1∶30 105 0.018 6
14# 70 1∶40 60 0.020 1
16# 70 1∶40 105 0.023 0
最优解 预测值 75 1∶50 150 0.036 1
实测值 75 1∶50 150 0.037 0
较优解1 预测值 75 1∶47 150 0.032 3
实测值 75 1∶47 150 0.019 8
较优解2 预测值 75 1∶46 150 0.031 5
实测值 75 1∶46 150 0.018 0

图2

芦丁标准品和黄麻纤维提取物的红外光谱图"

图3

黄麻纤维提取物的表面扫描电镜照片(×300)"

表6

黄麻纤维提取物元素组成及含量"

元素 质量百分比/% 标准偏差
C 69.81 0.90
O 24.87 0.84
Na 0.43 0.11
Si 2.14 0.14
Cl 1.11 0.14
K 0.67 0.14
Ca 0.97 0.18

图4

黄麻纤维提取物的热性能"

[1] 张蓓蓓. 植物黄酮类化合物的研究[J]. 科技视野, 2018(23):155-157.
ZHANG Beibei. Study on plant flavonoids[J]. Science & Technology Vision, 2018(23):155-157.
[2] 刘一杰, 薛永常. 植物黄酮类化合物的研究进展[J]. 中国生物工程杂志, 2016, 36(9):81-86.
LIU Yijie, XUE Yongchang. The research progress of flavonoids in plants[J]. China Biotechnology, 2016, 36(9):81-86.
[3] 高世会, 郁崇文. 罗布麻中黄酮的超临界CO2萃取及其抗菌性[J]. 纺织学报, 2018, 39(8):71-76,82.
GAO Shihui, YU Chongwen. Supercritical carbon dioxide extraction and bacterial resistance of flavones from apocynum venetum bast fiber[J]. Journal of Textile Research, 2018, 39(8):71-76,82.
[4] 韩立杰, 李影, 刘子菱, 等. 榛花粉水和乙醇提取物抗氧化性的比较[J]. 食品科技, 2014, 39(2):224-227.
HAN Lijie, LI Ying, LIU Ziling, et al. Anti-oxidation and antimicrobial activity of water and ethanol extracts from hazel pollen[J]. Food Science and Technology, 2014, 39(2):224-227.
[5] 刘伯渠, 卢新生, 党金宁. 微波法提取红洋葱总黄酮的研究[J]. 吉林师范大学学报(自然科学版), 2018, 39(3):90-94.
LIU Boqu, LU Xinsheng, DANG Jinning. Research on the flavonoid extracting technology by microwave from red onion[J]. Journal of Jilin Normal Univer-sity (Natural Science Edition), 2018, 39(3):90-94.
[6] 陈建福. 响应面优化超声辅助提取黄槿叶总黄酮工艺及其亚硝酸盐清除能力[J]. 食品工业科技, 2019, 40(6):193-197,204.
CHEN Jianfu. Optimization of ultrasonic assisted extraction of total flavonoids from hibiscus tilisceus leaves by response surface methodology and its scavenging ability of nitrite[J]. Science and Technology of Food Industry, 2019, 40(6):193-197,204.
[7] 曾承露, 李锋. 酶法提取黄饭花黄酮工艺优化及其抗氧化活性研究[J]. 中国食品添加剂, 2017(6):93-98.
ZENG Chenglu, LI Feng. The optimization of flavonoids extraction from buddleja officinalis maxim by enzymatic and flavonoids antioxidant activity[J]. China Food Additives, 2017(6):93-98.
[8] 黄春梅. 菜用黄麻叶多糖、黄酮的萃取及菜用黄麻叶面条制作的研究[D]. 福州:福建农林大学, 2013: 20.
HUANG Chunmei. Studies on extract polysaccharide and total flavonoids from jute, and how to made jute noodle[D]. Fuzhou: Fujian Agriculture and Forest University, 2013: 20.
[9] 杨永涛. 罗布麻总黄酮的提取、分离纯化及抗氧化性能研究[D]. 广州:华南理工大学, 2018: 31.
YANG Yongtao. Study on extraction, purification and antioxidant activity of total flavonoids from apocynum venetum[D]. Guangzhou: South China University of Technology, 2018: 31.
[10] 陈如冰, 周雪娜, 陈婉芳, 等. 长蒴黄麻总黄酮的提取及其抗氧化性[J]. 贵州农业科学, 2011, 39(10):162-165.
CHEN Rubing, ZHOU Xuena, CHEN Wanfang, et al. Extraction and antioxidant activity of total flavonoids from corchorus olitorius[J]. Guizhou Agricultural Sciences, 2011, 39(10):162-165.
[11] 刘毅, 冷娟, 刘亮亮, 等. 大麻叶中总黄酮提取工艺的优化及其抗氧化活性测定[J]. 中国麻业科学, 2019, 41(1):13-23.
LIU Yi, LENG Juan, LIU Liangliang, et al. Optimization of extraction process for total flavonoids from hemp leaves and their antioxidant activity measure[J]. Plant Fiber Sciences in China, 2019, 41(1):13-23.
[12] 郁崇文, 汪军, 王新厚. 工程参数的最优化设计[M]. 上海: 东华大学出版社, 2003: 108.
YU Chongwen, WANG Jun, WANG Xinhou. Optimal design of engineering parameters[M]. Shanghai: Donghua University Press, 2003: 108.
[13] 林泽华. 侧柏叶黄酮和多糖分离纯化、结构表征及活性评价[D]. 广州:华南理工大学, 2016: 68.
LIN Zehua. Purification and structural characterization of flavonoids and polysaccharides from platycladus orientalis (L.) franco leaves and their biological activities[D]. Guangzhou: South China University of Technology, 2016: 68.
[1] 陈玉香, 虞美雅, 董正梅, 缪璐璐, 林燕燕, 邹专勇. 喷气涡流纺纱线热黏合增强工艺优化与机制[J]. 纺织学报, 2020, 41(11): 48-52.
[2] 苗苗, 王晓旭, 王迎, 吕丽华, 魏春艳. 氧化石墨烯接枝聚丙烯非织造布的制备及其抗静电性[J]. 纺织学报, 2019, 40(11): 125-130.
[3] 高世会 郁崇文. 罗布麻中黄酮的超临界CO2萃取及其抗菌性[J]. 纺织学报, 2018, 39(08): 71-76.
[4] 邹专勇. 喷气涡流纺成纱工艺对竹浆纤维色纺纱性能的影响[J]. 纺织学报, 2014, 35(2): 23-0.
[5] 罗慧 张磊 林志行 刘剑 陈云媚 靳向煜 王洪. 薄型黄麻/低熔点纤维复合地膜材料的研制[J]. 纺织学报, 2013, 34(5): 47-52.
[6] 张勇兵 张婉 王强 范雪荣 袁久刚 王平 章金芳. 漆酶处理对黄麻纤维木质素结构的影响[J]. 纺织学报, 2013, 34(11): 94-0.
[7] 赵玉萍, 张娟, 郭雅琳, 赵明. 基于响应面分析法的超声波洗涤羽毛纤维工艺条件优化[J]. 纺织学报, 2012, 33(7): 24-30.
[8] 彭文芳;孙恩乐;杨树彬. 黄麻混纺交织物的风格测试与分析[J]. 纺织学报, 2010, 31(11): 54-56.
[9] 曲微微.;俞建勇.;刘丽芳.;李发学.;刘国忠. 可降解黄麻/PBS复合材料的结构与力学性能[J]. 纺织学报, 2008, 29(8): 52-55.
[10] 韩建.;袁利华;徐国平. PLA/黄麻复合层压材料的降解性能分析[J]. 纺织学报, 2008, 29(8): 48-51.
[11] 王春红;王瑞;于飞. 竹原纤维的化学脱胶工艺[J]. 纺织学报, 2007, 28(4): 26-29.
[12] 杜兆芳;张元明;黄晨;高春燕;胡凤霞;曹建飞. 黄麻/聚丙烯复合板材热压工艺参数的优化[J]. 纺织学报, 2006, 27(9): 47-50.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
京ICP备14006648号　 京公网安备11010502044800号
版权所有 © 2021 《纺织学报》编辑部
地址： 北京市朝阳区延静里中街3号主楼6层《纺织学报》杂志社　邮政编码：100025　
电话：010-65017711,65917740　传真：010-65016539　Email:fangzhixuebao@vip.126.com
本系统由北京玛格泰克科技发展有限公司设计开发