Journal of Textile Research ›› 2022, Vol. 43 ›› Issue (04): 90-96.doi: 10.13475/j.fzxb.20210202807

• Dyeing and Finishing & Chemicals • Previous Articles     Next Articles

Preparation of amino-modified Reactive Red 195/polymer nanospheres and its application on dyeing of cotton fabrics

WANG Dongwei1,2, FANG Kuanjun1,3,4(), LIU Xiuming1, ZHANG Xinqing5, AN Fangfang1   

  1. 1. School of Textile Science and Engineering, Tiangong University, Tianjin 300387, China
    2. School of Textiles, Zhongyuan University of Technology, Zhengzhou, Henan 450007, China
    3. State Key Laboratory for Bio-Fibers and Eco-Textiles, Qingdao University, Qingdao, Shandong 266071, China
    4. Eco-Textiles Collaborative Innovation Center of Shandong Province and the Ministry of Education, Qingdao, Shandong 266071, China
    5. School of Textile Science and Engineering, Xi'an Polytechnic University, Xi'an, Shaanxi 710048, China
  • Received:2021-02-09 Revised:2022-01-11 Online:2022-04-15 Published:2022-04-20
  • Contact: FANG Kuanjun E-mail:13808980221@163.com

RichHTML

20

PDF (PC)

84

Abstract:

In view of the problems that hydrolysis of reactive dyes leads to low utilization and environmental pollution, nanospheres were prepared by using ethylenediamine modified Reactive Red 195/polymer. The influence of initial bath pH value, mass fraction of ethylenediamine, temperature and time on the size and Zeta potential of amino-modified Reactive Red 195/polymer nanospheres were discussed, and the K/S values and color parameters of the cationic cotton fabrics dyed with the amino-modified Reactive Red 195/polymer nanospheres under the optimal conditions were investigated. The results show that the amino-modified Reactive Red 195/polymer nanospheres with an average hydration diameter of 96.5 nm, polydispersity index of 0.075 and Zeta potential of -33.7 mV were fabricated after modified with ethylenediamine under the conditions of the initial pH value 11, the mass fraction of ethylenediamine 40%, 60 ℃ for 120 min. The K/S value of the cationic cotton fabric dyed with the amino-modified Reactive Red 195/polymer nanospheres reaches up to 9.3, which is 3.1 times higher than the K/S value of the cotton fabric dyed with same dosage of Reactive Red 195, with improvement of color saturation. The rubbing and washing color fastness of dyed cotton fabrics are both equal to or higher than grade 4.

Key words: reactive dye, colored polymer nanosphere, cationic modification, cotton fabric dyeing

CLC Number: 

  • TS193.2

Fig.1

Effect of pH value on size and Zeta potential of amino-modified color polymer nanospheres"

Fig.2

Effect of ethylenediamine mass fraction on size and Zeta potential of amino-modified color polymer nanospheres"

Fig.3

Effect of temperature on size and Zeta potential of amino-modified color polymer nanospheres"

Tab.1

Effect of time on size and Zeta potential of amino-modified color polymer nanospheres"

改性时间/min 粒径/nm Zeta电位/mV
120 99.0 -34.1
240 97.7 -37.4

Fig.4

FT-IR spectra of ploymer nanospheres"

Fig.5

XPS spectra of ploymer nanospheres"

Tab.2

Analysis of polymer nanosphere surface elements"

聚合物微球 结合能/eV 元素含量/% 元素含量比
C1s O1s N1s C1s O1s N1s O与C含量比 N与C含量比
彩色微球 284.8 531.2 400.1 73.14 18.81 2.72 0.26 0.04
胺化彩色微球 78.54 13.57 4.36 0.17 0.06

Tab.3

Color values of dyed cotton fabrics"

色素 染料用量/
%(o.w.f)		 K/S
值		 L* a* b* C* h0
胺化彩
色微球		 0.5 1.9 62.7 42.5 -9.2 43.5 347.8
0.9 5.3 51.9 53.5 -7.0 54.0 352.6
1.4 9.3 46.9 57.9 -4.6 58.1 355.5
活性
染料		 0.5 1.3 67.1 40.0 -10.0 41.2 346.0
0.9 2.2 61.7 46.2 -10.3 47.3 347.4
1.4 3.0 58.4 49.5 -9.8 50.5 348.8

Fig.6

SEM images of cationic cotton fibers dyed with amino-modified color nanospheres at different magnification"

Tab.4

Color fastness of dyed cotton fabrics"

色素 染料用量/
%(o.w.f)		 耐摩擦色牢度/级 耐皂洗色牢度/级
干 湿 棉沾 毛沾 变色
胺化彩
色微球		 0.5 4 ~ 5 4 5 5 4 ~ 5
0.9 4 ~ 5 4 5 5 4 ~ 5
1.4 4 ~ 5 4 5 5 4
活性
染料		 0.5 5 4 ~ 5 5 5 4 ~ 5
0.9 4 ~ 5 4 5 5 4 ~ 5
1.4 4 ~ 5 4 5 5 4 ~ 5
[1] SHU Dawu, FANG Kuanjun, LIU Xiuming, et al. Cleaner coloration of cotton fabric with reactive dyes using a pad-batch-steam dyeing process[J]. Journal of Cleaner Production, 2018, 196: 935-942.
doi: 10.1016/j.jclepro.2018.06.080
[2] ZHANG Xinqing, FANG Kuanjun, ZHANG Jianfei, et al. A vacuum-dehydration aided pad-steam process for improving reactive dyeing of cotton fabric[J]. Journal of Cleaner Production, 2017, 168: 1193-1200.
doi: 10.1016/j.jclepro.2017.09.112
[3] KHATRI A, PEERZADA M H, MOHSIN M, et al. A review on developments in dyeing cotton fabrics with reactive dyes for reducing effluent pollution[J]. Journal of Cleaner Production, 2015, 87: 50-57.
doi: 10.1016/j.jclepro.2014.09.017
[4] 贾艳萍, 姜成, 郭泽辉, 等. 印染废水深度处理及回用研究进展[J]. 纺织学报, 2017, 38(8): 172-180.
JIA Yanping, JIANG Cheng, GUO Zehui, et al. Research progress on deep treatment and recycling of dye wastewater[J]. Journal of Textile Research, 2017, 38(8): 172-180.
[5] 陈小文, 吴伟, 钟毅, 等. 棉织物的活性染料低含水率焙蒸固色工艺[J]. 纺织学报, 2021, 42(7): 115-122.
CHEN Xiaowen, WU Wei, ZHONG Yi, et al. Low-moisture content baking and steaming color fixation process for cotton fabrics padded with reactive dyes[J]. Journal of Textile Research, 2021, 42(7): 115-122.
[6] 鲜永芳, 王红梅, 吴明华, 等. 少/无氨氮助剂在活性染料深色印花中的应用[J]. 纺织学报, 2021, 42(11): 89-96.
XIAN Yongfang, WANG Hongmei, WU Minghua, et al. Application of low/non-ammonia additives in reactive deep printing[J]. Journal of Textile Research, 2021, 42(11): 89-96.
doi: 10.1177/004051757204200204
[7] 张峰, 林红, 路艳华, 等. 端氨基超支化合物在棉织物活性染料染色中的应用[J]. 纺织学报, 2008, 29(2): 64-67.
ZHANG Feng, LIN Hong, LU Yanhua, et al. Application of amino-terminated hyperbranched polymers in reactive dyeing of cotton fabrics[J]. Journal of Textile Research, 2008, 29(2): 64-67.
[8] MOKHTARI J, PHILLIPS D A S, TAYLOR J A. Synthesis and evaluation of a series of trisazo hetero bi-functional reactive dyes for cotton[J]. Dyes and Pigments, 2005, 64: 163-170.
doi: 10.1016/j.dyepig.2004.05.007
[9] PASHA K, TAYLOR J A. The synthesis and application of novel 2-chloro-4-alkylthio triazinyl reactive dyes[J]. Dyes and Pigments, 2013, 96: 397-402.
doi: 10.1016/j.dyepig.2012.08.016
[10] WANG Guo, ZHENG Chun, SUN Jie. Synthesis and salt-free dyeing characteristics of cationic reactive dyes containing polyetheramine segments[J]. Coloration Technology, 2016, 132: 344-349.
doi: 10.1111/cote.12225
[11] 马辉. 基于聚乙烯亚胺结构的高分子活性染料的合成及应用[D]. 上海: 东华大学, 2012: 7-10, 26.
MA Hui. Synthesis and applications of polymeric reactive dyes based on polyethylene imine[D]. Shanghai: Donghua University, 2012: 7-10, 26.
[12] 鲁鹏, 洪思思, 林旭, 等. 活性染料/聚苯乙烯复合胶体微球的制备及其在桑蚕丝织物上的结构生色[J]. 纺织学报, 2021, 42(1): 90-95, 102.
LU Peng, HONG Sisi, LIN Xu, et al. Preparation of reactive dye/polystyrene composite colloidal microspheres and their structural coloring on silk fabrics[J]. Journal of Textile Research, 2021, 42(1): 90-95, 102.
[13] 王东伟, 房宽峻, 刘秀明, 等. 彩色聚合物微球的制备及其在纺织印染中应用的研究进展[J]. 纺织学报, 2019, 40(3): 175-182.
WANG Dongwei, FANG Kuanjun, LIU Xiuming, et al. Preparation of colored polymer microspheres and research progress thereof in textile dyeing and printing[J]. Journal of Textile Research, 2019, 40(3): 175-182.
[14] 夏效杰, 房宽峻, 任斌, 等. 分散染料染色法制备的彩色聚(苯乙烯-丙烯酸)纳米球[J]. 应用化学, 2015, 32(1): 64-70.
doi: 10.11944/j.issn.1000-0518.2015.01.140117
XIA Xiaojie, FANG Kuanjun, REN Bin, et al. Colored poly(styrene-co-acrylic acid)nanospheres prepared by dyeing with disperse dyes[J]. Chinese Journal of Applied Chemistry, 2015, 32(1): 64-70.
doi: 10.11944/j.issn.1000-0518.2015.01.140117
[15] SONG Yawei, FANG Kuanjun, REN Yanfei, et al. Inkjet printable and self-curable disperse dyes/P(St-BA-MAA) nanosphere inks for both hydrophilic and hydrophobic fabrics[J]. Polymers, 2018, 10(12): 1402.
doi: 10.3390/polym10121402
[16] FANG Kuanjun, XIE Ruyi, LIU Xiuming, et al. Reactive dye/poly(styrene-co-butyl acrylate-co-trimethyl(vinylbenzyl) ammonium chloride) nanospheres with high coloration performance for cleaner dyeing of cotton fabrics[J]. Cellulose, 2019, 26(9): 5807-5819.
doi: 10.1007/s10570-019-02498-7
[17] WANG Dongwei, FANG Kuanjun, LIU Xiuming, et al. Amino-modified Reactive Red 195/P(styrene-co-butyl acrylate-co-trimethyl(vinylbenzyl) ammonium chloride) nanospheres with high coloration performance for enhancing cotton dyeability[J]. Textile Research Journal, 2021, 91: 1104-1116.
doi: 10.1177/0040517520974043
[18] 周岚, 邵建中, 柴丽琴. 阳离子改性剂在棉纤维天然染料染色中的应用[J]. 纺织学报, 2009, 30(10): 95-100, 105.
ZHOU Lan, SHAO Jianzhong, CHAI Liqin. Application of cationic modification agent to dyeing of cotton with natural dyes[J]. Journal of Textile Research, 2009, 30(10): 95-100, 105.
[19] 陈桂淋, 辛宝平, 郑文钗, 等. 黑曲霉吸附弱酸性艳蓝RAWL机理研究[J]. 应用与环境生物学报, 2007, 13: 353-356.
CHEN Guilin, XIN Baoping, ZHENG Wenchai, et al. Mechanism of biosorption of weak acid brilliant blue RAWL by biosorbent derived from aspergillusniger[J]. Chinese Journal of Applied Environmental Biology, 2007, 13: 353-356.
[20] ZAUCHA M, ADAMCZYK Z, BARBASZ J. Zeta potential of partical bilayers on mica: a streaming potential study[J]. Journal of Colloid and Interface Science, 2011, 360: 195-203.
doi: 10.1016/j.jcis.2011.02.025
[21] 韩冬梅, 房宽峻, 蔡玉青, 等. 反应性P(St-BA-VBT)/染料复合纳米球的制备[J]. 功能高分子学报, 2015, 28(2): 220-224.
HAN Dongmei, FANG Kuanjun, CAI Yuqing, et al. Preparation of reactive P(St-BA-VBT)/dye composite nanospheres[J]. Journal of Functional Polymers, 2015, 28(2): 220-224.
[22] SONG Yawei, FANG Kuanjun, BUKHARI M N, et al. Disperse dye/poly(styrene-methacrylic acid) nanospheres with high coloration performance for textiles[J]. Journal of Cleaner Production, 2020, 163: 121538.
[1] PEI Liujun, SHI Wenhua, ZHANG Hongjuan, LIU Jinqiang, WANG Jiping. Technology progress and application prospect of non-aqueous medium dyeing systems [J]. Journal of Textile Research, 2022, 43(01): 122-130.
[2] XIAN Yongfang, WANG Hongmei, WU Minghua, WANG Lili. Application of low/non-ammonia additives in reactive deep printing [J]. Journal of Textile Research, 2021, 42(11): 89-96.
[3] LI Chang, FANG Kuanjun, LIU Xiuming, AN Fangfang, LIANG Yingchao, LIU Hao. Effect of cationic modification in hydrophobic system on ink droplet spreading on cotton/polyamide fabrics [J]. Journal of Textile Research, 2021, 42(09): 112-119.
[4] CHEN Xiaowen, WU Wei, ZHONG Yi, XU Hong, MAO Zhiping. Low-moisture content baking and steaming color fixation process for cotton fabrics padded with reactive dyes [J]. Journal of Textile Research, 2021, 42(07): 115-122.
[5] XU Baolü, WU Wei, ZHONG Yi, XU Hong, MAO Zhiping. Simulation study on effect of organic solvents on dispersion and hydrolytic stability of liquid reactive dyes [J]. Journal of Textile Research, 2021, 42(02): 113-121.
[6] HE Xuemei, MAO Haiyan, CAI Lu. Adsorption performance of chitosan based hybrid aerogel on reactive dyes [J]. Journal of Textile Research, 2021, 42(02): 148-155.
[7] LU Peng, HONG Sisi, LIN Xu, LI Hui, LIU Guojin, ZHOU Lan, SHAO Jianzhong, CHAI Liqin. Preparation of reactive dye/polystyrene composite colloidal microspheres and their structural coloring on silk fabrics [J]. Journal of Textile Research, 2021, 42(01): 90-95.
[8] LI Qing, GUAN Binbin, WANG Ya, LIU Tianhui, ZHANG Luohong, FAN Zenglu. Photosensitizers sensitized Cu-organic framework for highly efficient photocatalytic degradation of Reactive Dark Blue K-R [J]. Journal of Textile Research, 2020, 41(10): 87-93.
[9] DING Yongsheng, DAI Yamin, ZHONG Yi, XU Hong, MAO Zhiping, ZHANG Linping, CHEN Zhize. Dyeing kinetics of reactive dye on cotton yarn in Pickering emulsion system [J]. Journal of Textile Research, 2020, 41(07): 101-108.
[10] ZHANG Wei, MAO Qingkai, ZHU Peng, CHAI Xiong, LI Huijun. Kinetic and thermodynamic of reactive dye study on silk fabric modification in ethanol/water system [J]. Journal of Textile Research, 2020, 41(06): 86-92.
[11] WU Wei, CHEN Xiaowen, ZHONG Yi, XU Hong, MAO Zhiping. Role of sodium sulfate in low add-on pad-cure-steam reactive dyeing process [J]. Journal of Textile Research, 2020, 41(05): 85-93.
[12] WANG Qiuping, MAO Zhiping, ZHONG Yi, XU Hong, ZHANG Linping. Influence of knitted deformation on dyeing in flat pad dyeing [J]. Journal of Textile Research, 2019, 40(11): 94-99.
[13] YANG Haizhen, FANG Kuanjun, LIU Xiuming, CAI Yuqing, AN Fangfang, HAN Shuang. Influence of cotton fabric structure on ink droplet spreading and color performance [J]. Journal of Textile Research, 2019, 40(07): 78-84.
[14] TAO Kaixin, YU Chengbing, HOU Qi'ao, WU Congjie, LIU Yinfeng. Wet-steaming dyeing prediction model of cotton knitted fabric with reactive dye based on least squares support vector machine [J]. Journal of Textile Research, 2019, 40(07): 169-173.
[15] WANG Aming, XIA Liangjun, WANG Yunli. Aggregation behavior of Reactive Red 195 in neutral electrolyte solution [J]. Journal of Textile Research, 2019, 40(04): 77-82.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
京ICP备14006648号
Copyright 2021 © Editorial office of Journal of Textile Research
Supported by Beijing Magtech Co.Ltd