Journal of Textile Research ›› 2018, Vol. 39 ›› Issue (12): 30-36.doi: 10.13475/j.fzxb.20180300907

Previous Articles     Next Articles

Correlation analysis on relationship between short fiber content of  card sliver and yarn parameters

  

  • Received:2018-03-01 Revised:2018-09-14 Online:2018-12-15 Published:2018-12-17

PDF (PC)

108

Abstract:

To explore the influence of short fiber content (SFC) in card sliver on yarn parameters and make a prediction, the card sliver and yarn were produced under different speeds of cylinder and takein. The card sliver was tested with USTER AFIS and less than 10, 12, 14 and 16 mm SFC were calculated, respectively, according to fiber length distribution of card sliver. The evenness, hairiness and strength of yarn were tested by unevenness tester, hairiness tester and strength tester, respectively. The correlation coefficients between 4 SFC parameters and yarn parameters with SPSS were calculated. The results show that a high correlation exists between SFC and evenness parameters, but a little correlation exists between SFC and strength parameters, even negative correlation in hairiness parameters, so it is predicted that the yarn quality is necessary according to SFC of card sliver based on actual carding technology.

Key words: card sliver, short fiber content, evenness, hairiness, yarn strength

[1] 曹继鹏，于学智，赵博. 纺纱质量控制[M]. 北京：中国纺织出版社，2017:65-71.
CAO Jipeng, YU Xuezhi, ZHAO Bo. Spinning Quality Control[M]. Beijing: China Textile & Apparel Press, 2017:65-71.
[2] 林倩,严广松,郁崇文.棉纤维长度分布密度函数的非参数核估计[J].纺织学报,2008,29 (11):22-25.
LIN Qian, YAN Guangsong, YU Chongwen. Non-parameter kernel estimation of density function of cotton fiber length[J]. Journal of Textile Research,2008, 29(11):22-25.
[3] 张朝辉,李梅.原棉性能与纱线强力的关系[J].纺织学报,2005, 26(1):52-53.
ZHANG Chaohui, LI Mei. Relationship between raw cotton property and yarn strength[J]. Journal of Textile Research,2005, 26(1):52-53.
[4] 吕立斌,杜梅,陈春燕.梳棉生条质量与纱线质量关系的研究[J].棉纺织技术,2007,35(4):30-33.
Lü Libin, DU Mei, Chen Chunyan. Research of Relation between Card Sliver Quality and Yarn Quality[J]. Cotton Textile Technology,2007,35(4):30-33.
[5] 杜梅.梳棉生条质量与纱线质量的灰色关联分析[J].广西纺织科技,2008,37(3):27-28.
DU Mei. Grey correlation degree analysis between card sliver quality and yarn quality[J].Guangxi Textile Technology, 2008, 37(3):27-28.
[6] THIBODEAUX D., SENTER H., KNOWLTON J.L., et al. The impact of short fiber content on the quality of cotton ring spun yarn[J]. The Journal of Cotton Science, 2008,12(4):368-377.
[7] CHANSELME J.,HEQUET E., FRYDRYCH R. Relationship between AFIS fiber characteristics and yarn evenness and imperfections[C]//Proc. Beltwid Cotton Conf., New Orleans, LA.,1997:512-516.
[8] HEQUET E. Application of the AFIS multidata[C]//Proc. Beltwid Cotton Conf., Orlando, FL., 2000:666-670.
[9] 瞿建增.短纤维含量与成纱质量的关系[J].棉纺织技术,1986,4(3): 23-26.
QU Jianzeng.The relation between staple fibre content and yarn quality[J]. Cotton Textile Technology, 1986,4(3): 23-26.
[10] SRINIVASAN V., DHANDAYUTHAPANI C. Relative SFC measurement and its effect on yarn quality[J]. The Indian Textile Journal, 2007,5:32-33.
[11] CAO Jipeng, LU Qin, SUN, Pengzi, et al. Test stability of Uster advanced fiber information system (AFIS) [J]. Journal of Donghua University (English Edition), 2010, 27(3):412-418.
[12] 刘恒琦. 纱线质量检测与控制[M].北京：中国纺织出版社，2008：104-105.
LIU Hengqi. The test and control of yarn quality[M]. Beijing: China Textile & Apparel Press, 2008：104-105.
[13] 于加勇,丁晓娟.棉纤维长度整齐度与成纱质量的关系[J].棉纺织技术, 2004,33(7): 27-29.
YU Jiayong, Ding Xiaojuan. Relationship of Cotton Fiber Length Regularity with Yarn Forming Quality[J]. Cotton Textile Technology, 2004,33(7): 27-29.
[14] 徐少范，张尚勇. 棉纺质量控制[M].北京：中国纺织出版社，2011:154-155.
XU Shaofan, ZHANG Shangyong. Cotton Spinning Quality Control[M]. Beijing, China Textile & Apparel Press, 2011:154-155.
[1] . Design on pressure compatibility model of evenness roll [J]. Journal of Textile Research, 2018, 39(11): 158-162.
[2] . Numerical simulation for twisting chamber of air jet vortex spinning based on hollow spindle with spiral guiding grooves [J]. Journal of Textile Research, 2018, 39(09): 139-145.
[3] . Detection and evaluation on yarn hairiness of blackboard with image processing [J]. JOURNAL OF TEXTILE RESEARCH, 2018, 39(08): 144-149.
[4] . Reducing yarn hairiness by wetting in ring spinning [J]. JOURNAL OF TEXTILE RESEARCH, 2018, 39(05): 108-112.
[5] . Influence of sizing pretreatment agent in properties of warp knitting cotton yarn  [J]. JOURNAL OF TEXTILE RESEARCH, 2018, 39(04): 82-86.
[6] . Mechanism of swirl nozzle on yarns with different linear densites [J]. JOURNAL OF TEXTILE RESEARCH, 2018, 39(03): 38-44.
[7] . Influence of different drawing methods on appearance and yarn quality of cloud yarn [J]. JOURNAL OF TEXTILE RESEARCH, 2017, 38(12): 43-48.
[8] . Properties of flax and hemp blended yarn based on swirl nozzle spinning [J]. JOURNAL OF TEXTILE RESEARCH, 2017, 38(10): 19-24.
[9] . Tracking measurement of yarn hairiness skeleton and length [J]. JOURNAL OF TEXTILE RESEARCH, 2017, 38(08): 32-38.
[10] . Double S curves soft drafting technology [J]. JOURNAL OF TEXTILE RESEARCH, 2017, 38(07): 34-38.
[11] . Principle and analysis of slub yarns spun by three-channel digital ring spinning [J]. JOURNAL OF TEXTILE RESEARCH, 2017, 38(07): 39-43.
[12] . Yarn evenness detection based on saliency algorithm [J]. JOURNAL OF TEXTILE RESEARCH, 2017, 38(06): 130-135.
[13] . Modeling and experimental study on yarn’s cross-section compression deformation [J]. JOURNAL OF TEXTILE RESEARCH, 2017, 38(02): 184-190.
[14] . Automatic construction of digital woven fabric using sequence yarn images [J]. Journal of Textile Research, 2016, 37(3): 35-40.
[15] . Size-free sizing process for cellulosic yarns [J]. Journal of Textile Research, 2016, 37(2): 85-91.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
[1] . [J]. JOURNAL OF TEXTILE RESEARCH, 1986, 7(04): 44 .
[2] . [J]. JOURNAL OF TEXTILE RESEARCH, 2004, 25(03): 55 -56 .
[3] CHEN Zong-nong;ZANG Guo-jie;ZHAN Jian-chao. Application of embedded system in the high speed loom control system[J]. JOURNAL OF TEXTILE RESEARCH, 2006, 27(9): 29 -31 .
[4] . [J]. JOURNAL OF TEXTILE RESEARCH, 1981, 2(04): 7 -16 .
[5] . [J]. JOURNAL OF TEXTILE RESEARCH, 2004, 25(01): 68 -69 .
[6] . [J]. JOURNAL OF TEXTILE RESEARCH, 2004, 25(06): 19 -21 .
[7] . [J]. JOURNAL OF TEXTILE RESEARCH, 1992, 13(07): 27 -30 .
[8] . [J]. JOURNAL OF TEXTILE RESEARCH, 2004, 25(03): 94 -95 .
[9] HU Danting;WANG Peixia. Industrial upgrading of Chinese apparel based on the theory of global value chain[J]. JOURNAL OF TEXTILE RESEARCH, 2007, 28(12): 131 -134 .
[10] . [J]. JOURNAL OF TEXTILE RESEARCH, 1998, 19(05): 28 -30 .
京ICP备14006648号
Copyright 2021 © Editorial office of Journal of Textile Research
Supported by Beijing Magtech Co.Ltd