Journal of Textile Research ›› 2019, Vol. 40 ›› Issue (01): 91-96.doi: 10.13475/j.fzxb.20180201206

• Dyeing and Finishing & Chemicals • Previous Articles     Next Articles

Application of copper complex in low-temperature neutral bleaching of cotton knitted fabrics

WU Chenren, LÜ Wangyang(), CHEN Wenxing   

  1. National Engineering Laboratory for Textile Fiber Materials & Processing Technology, Zhejiang Sci-Tech University, Hangzhou, Zhejiang 310018, China
  • Received:2018-02-15 Revised:2018-08-08 Online:2019-01-15 Published:2019-01-18
  • Contact: Lü Wangyang E-mail:luwy@zstu.edu.cn

RichHTML

6

PDF (PC)

211

Abstract:

For the excessive energy consumption in the conventional high temperature bleaching processes of cotton fabrics, a copper complex with iminodiacetic acid, bivalent copper ions and pyridine derivatives was used as the catalyst for hydrogen peroxide low temperature bleaching to construct a novel low temperature cotton knitted fabric bleaching system. The effects of temperature, concentration of complex, bleaching time, mass concentration of sodium hydroxide and concentration of hydrogen peroxide mass of on bleaching effect of cotton knitted fabric were discussed. At the same time, the degradation process of p-coumaric acid as the model compound of lignin was studied and the mechanism of catalytic bleaching of cotton knitted fabric in the presence of copper complex catalyst was proposed. By single factor test, the final optimized bleaching process was determined as follows: metal complex of 30 μmol/L, 30% H2O2 of 10 g/L, penetrant agent of 2 g/L, scouring agent of 2 g/L, liquor ratio of 1∶30, and bleaching at 60 ℃ for 60 min. Under the neutral condition, the whiteness of the treated fabric can reach 75.03%, and the bursting strength loss is smaller.

Key words: metal complex, hydrogen peroxide, low-temperature bleaching, cotton knitted fabric

CLC Number: 

  • TS192.5

Fig.1

Synthesis route of IDA/Cu(II)/4-ampy"

Tab.1

Effect of NaOH concentration on whiteness index of fabric"

氢氧化钠质量
浓度/(g·L-1)		 CIE白度/% 氢氧化钠质量
浓度/(g·L-1)		 CIE白度/%
0 75.73 3 70.94
1 69.17 4 71.08
2 70.88

Fig.2

Effect of H2O2 concentration on whiteness index of fabric"

Fig.3

Effect of complex concentration on whiteness index of fabric"

Fig.4

Effect of bleaching temperature on whiteness index of fabric"

Fig.5

Effect of bleaching time on whiteness index of fabric"

Tab.2

Results of low temperature bleaching experiments"

试样 CIE白度/% 润湿性/s 顶破强力/N
精练布 25.21 小于1.0 342.22
对照组试样 31.03 小于1.0 310.14
低温优化工艺试样 75.03 小于1.0 302.48

Fig.6

Oxidation effect of complex on p-coumaric acid"

Fig.7

High-definition mass spectra analysis of metal complex(a) and high valence-copper-reactive species(b)"

Fig.8

Catalytic mechanism of IDA/Cu(II)/4-ampy complex"

[1] 刘梦杰. 纯棉织物低温氧漂助剂及其工艺研究[D]. 上海:东华大学, 2015: 1-20.
LIU Mengjie. Low-temperture oxidation bleaching auxiliaries and processing technology of pure cotton fabric[D]. Shanghai: Donghua University, 2015: 1-20.
[2] 杨栋梁, 王焕祥. 活化双氧水漂白体系新技术的近况:一[J]. 印染, 2007,33(2):44-48.
YANG Dongliang, WANG Huanxiang. Current situation of activated system of hydrogen peroxide bleaching:I[J]. China Dyeing & Finishing, 2007,33(2):44-48.
[3] 陈荣圻. 开发节能型氧漂活化剂[J]. 染整技术, 2008,30(10):1-6.
CHEN Rongqi. Development of energy saying oxygen bleaching activators[J]. Textile Dyeing and Finishing Journal, 2008,30(10):1-6.
[4] SHAO J Z, HUANG Y, WANG Z H, et al. Cold pad-batch bleaching of cotton fabrics with a TAED/H2O2 activating system[J]. Coloration Technology, 2010,126(2):103-108.
doi: 10.1111/(ISSN)1478-4408
[5] 崔双双, 张艳, 高加勇, 等. 棉织物低温氧漂活化剂的制备[J]. 纺织学报, 2016,37(7):88-92.
CUI Shuangshuang, ZHANG Yan, GAO Jiayong, et al. Synjournal of peroxide activator for low-temperature bleaching of cotton fabric[J]. Journal of Textile Research, 2016,37(7):88-92.
[6] 秦新波, 宋敏, 尹冲, 等. 金属配合物的合成及其在低温漂白中的应用[J]. 纺织学报, 2012,33(11):72-76.
QIN Xinbo, SONG Min, YIN Chong, et al. Synjournal of metal complex and its application in low temperature bleaching[J]. Journal of Textile Research, 2012,33(11):72-76.
[7] 任参, 宋敏, 张琳萍, 等. 金属酞菁配合物在催化双氧水漂白棉型织物中的应用[J]. 纺织学报, 2012,33(1):81-86.
REN Can, SONG Min, ZHANG Linping, et al. Application of metal phthalocyanine complex to hydrogen peroxide bleaching of cotton fabrics[J]. Journal of Textile Research, 2012,33(1):81-86.
[8] SOROKIN A B. Phthalocyanine metal complexes in catalysis[J]. Chemical Reviews, 2013,113(10):8152-8191.
pmid: 23782107
[9] LIM C L, MORAD N, TENG T T, et al. Treatment of Terasil Red R dye wastewater using H2O2/pyridine/Cu(II) system[J]. Journal of Hazardous Materials, 2009,168(1):383-389.
doi: 10.1016/j.jhazmat.2009.02.061 pmid: 19303709
[10] 秦新波, 尹冲, 宋敏, 等. 双核锰配合物在低温漂白中的活化作用[J]. 印染, 2011,37(21):1-5.
QIN Xinbo, YIN Chong, SONG Min, et al. Activation of binuclear manganese complex in low temperature bleaching[J]. China Dyeing & Finishing, 2011,37(21):1-5.
[11] 黄益, 李思琪, 阮斐斐, 等. 卟啉铁/双氧水体系在棉织物低温催化漂白中的应用[J]. 纺织学报, 2018,39(6):75-80.
HUANG Yi, LI Siqi, RUAN Feifei, et al. Application of porphyrin iron/H2O2 system in low temperature bleaching of cotton fabrics[J]. Journal of Textile Research, 2018,39(6):75-80.
[12] 尹冲, 黄瑜婷, 鲁玉洁, 等. 铜配合物在低温催化漂白棉针织物中的应用[J]. 印染, 2014,40(6):6-10.
YIN Chong, HUANG Yuting, LU Yujie, et al. Application of copper complex to catalytic bleaching of cotton knits at low temperature[J]. China Dyeing & Finishing, 2014,40(6):6-10.
[13] WANG X Y, TANG J L. An evaluation of the effectiveness of applying a gelatin-copper complex in the low-temperature bleaching of cotton with hydrogen peroxide[J]. Coloration Technology, 2017,133:300-304.
doi: 10.1111/cote.2017.133.issue-4
[14] WANG Y Y, XIA H C, SUN K, et al. Insights into the generation of high-valent copper-oxo species in ligand-modulated catalytic system for oxidizing organic pollutants[J]. Chemical Engineering Journal, 2016,304:1000-1008.
doi: 10.1016/j.cej.2016.07.007
[15] LI N, LU W Y, PEI K M, et al. Formation of high-valent cobalt-oxo phthalocyanine species in a cellulose matrix for eliminating organic pollutants[J]. Applied Catalysis B: Environmental, 2015,163:105-112.
doi: 10.1016/j.apcatb.2014.07.056
[1] XIANG Zhong, WANG Yuhang, WU Jinbo, QIAN Miao, HU Xudong. Research progress in detection of hydrogen peroxide concentration [J]. Journal of Textile Research, 2020, 41(10): 197-204.
[2] HE Qingqing, XU Hong, MAO Zhiping, ZHANG Linping, ZHONG Yi, LÜ Jingchun. Preparation of high-electrical conductivity polypyrrole-coated fabrics [J]. Journal of Textile Research, 2019, 40(10): 113-119.
[3] ZHANG Yue, HU Danling, REN Jinna, LI Qing. Scouring and bleaching of cotton fabric by low temperature near neutrality one-bath one-step process [J]. Journal of Textile Research, 2019, 40(09): 83-90.
[4] . Low-temperature bleaching of cotton knitted fabrics using hydrogen peroxide in presence of copper complex catalysts [J]. Journal of Textile Research, 2019, 40(08): 101-108.
[5] . Wet-steaming dyeing prediction model of cotton knitted fabric with reactive dye based on least squares support vector machine [J]. Journal of Textile Research, 2019, 40(07): 169-173.
[6] . Preparation ana durable antibacterial fabric loaded with doped nano-TiO2 [J]. JOURNAL OF TEXTILE RESEARCH, 2017, 38(06): 163-168.
[7] . Evaluation of energy conservation and emissions reduction of enzyme oxygen pretreatment [J]. JOURNAL OF TEXTILE RESEARCH, 2014, 35(6): 74-0.
[8] . Influence of pretreatment of hydrogen peroxide on homochromaticity of half degumming silk∕cotton mixed fabrics dyed with reactive dyes [J]. JOURNAL OF TEXTILE RESEARCH, 2013, 34(12): 85-0.
[9] . Synergistic effect of TBCC/MnTACN system in low temperature bleaching with hydrogen peroxide [J]. JOURNAL OF TEXTILE RESEARCH, 2012, 33(9): 82-87.
[10] . Synthesis of metal complex and its application in low temperature bleaching [J]. JOURNAL OF TEXTILE RESEARCH, 2012, 33(11): 72-76.
[11] YUAN Ailin;WANG Jian;CHEN Tianlong. Room-temperature bleaching of cotton fabrics with chitosan-metal complexes /H2O2 [J]. JOURNAL OF TEXTILE RESEARCH, 2010, 31(10): 66-69.
[12] JIN Heling;ZHANG Yuping. Characterization of cotton knitted fabric treated with alkaline pectinase by FT-IR ATR spectroscopy [J]. JOURNAL OF TEXTILE RESEARCH, 2010, 31(1): 81-84.
[13] LENG Shaixiang;QIANG Guoshi;HUA Zhaozhe;DU Guocheng;CHEN Jian. Effect of catalase-treated bleach effluents on the process of reactive dyeing [J]. JOURNAL OF TEXTILE RESEARCH, 2007, 28(7): 77-81.
[14] LI Jin-hua. Application of activator ABO in hydrogen peroxide bleaching of flax yarn [J]. JOURNAL OF TEXTILE RESEARCH, 2006, 27(12): 96-98.
[15] WANG Qiang;FAN Xue-rong;YU Xiao-ru. [J]. JOURNAL OF TEXTILE RESEARCH, 2005, 26(6): 50-52.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
京ICP备14006648号
Copyright 2021 © Editorial office of Journal of Textile Research
Supported by Beijing Magtech Co.Ltd